走行轮轮胎带束层帘线性能参数对轮胎磨损影响规律研究

doi:10.3969/j.issn.1674-0696.2022.05.20

重庆交通大学学报（自然科学版） ›› 2022, Vol. 41 ›› Issue (05): 151-156.DOI: 10.3969/j.issn.1674-0696.2022.05.20

走行轮轮胎带束层帘线性能参数对轮胎磨损影响规律研究

文孝霞1，田云坤1，杜子学2

(1. 重庆交通大学机电与车辆工程学院，重庆 40074； 2. 重庆交通大学轨道交通研究院，重庆 400074)

收稿日期:2020-06-15 修回日期:2021-06-19 发布日期:2022-05-26
作者简介:文孝霞（1977—），女，贵州遵义人，副教授，博士，主要从事车辆工程方面的研究。E-mail：wenxiaoxia150@163.com
基金资助:
国家自然科学基金项目（51475062）

Influence Rule of Belt Cord Performance Parameters of Running Wheel Tire on Tire Wear

WEN Xiaoxia1, TIAN Yunkun1, DU Zixue2

(1. School of Mechatronics & Vehicle Engineering, Chongqing Jiaotong University, Chongqing 400074, China; 2. Institute of Urban Rail, Chongqing Jiaotong University, Chongqing 400074, China)

Received:2020-06-15 Revised:2021-06-19 Published:2022-05-26

摘要/Abstract

摘要： 跨座式单轨车辆的走行轮胎在实际运行中会发生严重的磨损。为厘清走行轮胎带束层帘线弹性模量和角度变化对轮胎磨损性能的影响规律，以走行轮径向刚度参数作为轮胎磨损性能的评价指标，对走行轮胎径向刚度随不同带束层帘线弹性模量和带束层帘线角度的变化规律进行研究；并对带束层帘线角度影响因子进行灵敏度分析。研究结果表明：带束层帘线弹性模量对轮胎的磨损性能影响较小；走行轮胎第2带束层帘线角度对轮胎的磨损性能影响程度最大、最敏感；第2带束层帘线角度越大，走行轮胎磨损性能越差；第1、3带束层帘线角度越大，走行轮胎磨损性能越好。

关键词: 车辆工程；单轨车辆，带束层；灵敏度；磨损性能；径向刚度

Abstract: The running wheel tires of straddle type monorail vehicles will be seriously worn in actual operation. In order to clarify the influence rule of elastic modulus and angle change of belt ply cord on tire wear performance, the radial stiffness of running wheel was taken as the evaluation index of tire wear performance. The variation rule of radial stiffness of running wheel tire changing with different elastic modulus of belt ply cord and angle of belt ply cord was studied, and the sensitivity analysis of the influence factors of the angle of the belt ply cord was carried out. The research results show that the elastic modulus of belt ply cord has little effect on the wear performance of tire; the second belt ply cord angle of the running wheel tire has the greatest and most sensitive effect on the wear performance of tire; the larger the second belt ply cord angle, the worse the wear performance of running wheel tire; the larger the first and third belt ply cord angles, the better the wear performance of running wheel tire.

Key words: vehicle engineering; monorail vehicle; belt layer; level of sensitivity; wear performance; radial stiffness

中图分类号:

U232

文孝霞1，田云坤1，杜子学2. 走行轮轮胎带束层帘线性能参数对轮胎磨损影响规律研究[J]. 重庆交通大学学报（自然科学版）, 2022, 41(05): 151-156.

WEN Xiaoxia1, TIAN Yunkun1, DU Zixue2. Influence Rule of Belt Cord Performance Parameters of Running Wheel Tire on Tire Wear[J]. Journal of Chongqing Jiaotong University(Natural Science), 2022, 41(05): 151-156.

参考文献

［1］仲建华，杜子学，何希和.跨座式单轨交通车辆道岔及结构分析［M］.北京：人民交通出版社，2013.
ZHONG Jianhua, DU Zixue, HE Xihe. Structure and Analysis of Switch for Straddle Type Monorail Vehicle［M］. Beijing: China Communications Press, 2013.
［2］ RODOVALHO E D C, TOMI G D. Reducing environmental impacts via improved tire wear management［J］. Journal of Cleaner Production, 2017, 141: 1419-1427.
［3］郑州.跨座式单轨列车走行轮胎偏磨损机理及控制方法研究［D］.镇江：江苏大学，2017.
ZHENG Zhou. Study on Shoulder Wear Mechanism and Control Method of Straddle-Type Monorail Trains Running Wheel Tires［D］. Zhenjiang: Jiangsu University,
2017.
［4］杜子学，文孝霞，杨震，等.跨座式单轨车辆走行轮偏磨损因子模型研究［J］.西南交通大学学报，2019，54(2)：373-380.
DU Zixue, WEN Xiaoxia, YANG Zhen, et al. Study on partial-wear-factor model monorail vehicle running wheel［J］. Journal of Southwest Jiaotong University, 2019, 54(2):
373-380.
［5］文孝霞，杜子学，许舟洲，等.单轨车辆耦合动力学模型与振动响应特性［J］.振动.测试与诊断，2017，37(3)：462-468.
WEN Xiaoxia, DU Zixue, XU Zhouzhou, et al. The coupling dynamic model and vibration response of straddle type monorail vehicle［J］. Jour-nal of Vibration,
Measurement & Diagnosis, 2017, 37(3): 462-468.
［6］文孝霞，杜子学，许舟洲，等.基于降低走行轮偏磨损的单轨车辆结构参数优化研究［J］.现代制造工程，2016(12)：9-15，93.
WEN Xiaoxia, DU Zixue, XU Zhouzhou, et al. Influence research of structural parameters on running wheel shoulder wear of the monorail vehicle［J］. Modern
Manufacturing Engineering, 2016(12): 9-15, 93.
［7］文孝霞，杜子学，左长永，等.曲线工况下跨座式单轨走行轮侧偏刚度对轮胎磨损的影响［J］.交通运输工程学报，2014，14(2)：41-48.
WEN Xiaoxia, DU Zixue, ZUO Changyong, et al. Influence of cornering stiffness of straddle-type monorail running wheel on tire wear under curve negotiating ［J］.
Journal of Traffic Transportation Engineering, 2014,14(2): 41-48.
［8］张松.跨座式单轨列车走行轮轮胎工作模态与偏磨关系研究［D］.镇江：江苏大学，2018.
ZHANG Song. Study on the Relationship between Operating Modal and Shoulder Wear of Straddle-Type Monorail Trains Running Wheel Tires［D］. Zhenjiang: Jiangsu
University, 2018.
［9］梁晖，王国林，梁晨，等.行驶面宽度和弧度高对轮胎偏磨损影响的有限元分析［J］.橡胶工业，2019，66(3)：207-212.
LIANG Hui, WANG Guolin, LIANG Chen, et al. Finite element analysis of effect of running surface width and arc height on tire uneven wear［J］. China Rubber Industry,
2019, 66(3): 207-212.
［10］朱新静，朱作勇，赵鹏翔，等.轮胎带束层结构变化对固有频率的影响研究［J］.轮胎工业，2017，37(5)：259-263.
ZHU Xinjing, ZHU Zuoyong, ZHAO Pengxiang, et al. Influence of belt structure on tire natural frequency［J］. Tire Industry, 2017, 37(5): 259-263.
［11］陈亮.双轴转向架单轨走行轮胎偏磨损分析及影响因素研究［D］.重庆：重庆交通大学，2017.
CHEN Liang. Partial Wear Analysis and Influence Factors Study of Running Tire about Double Axle Bogie Monorail［D］. Chongqing: Chongqing Jiaotong University, 2017.
［12］ WANG F. Vehicle running stability and evaluation index［J］. Vehicle System Dynamics, 2009: 15-31.
［13］ GIM G H, NIKRAVESH P E. An analytical model of pneumatic tires for vehicle dynamic simulations. Part 1: Pure slips［J］. International Journal of Vehicle Design,
1990, 11(6): 589-618.
［14］ GIM G H, NIKRAVESH P E. An analytical model of pneumatic tires for vehicle dynamic simulations. Part 2: Comprehensive slips［J］. International Journal of Vehicle
Design, 1991, 12(1): 19-39.
［15］ GIM G H, NIKRAVESH P E. An analytical model of pneumatic tires for vehicle dynamic simulations. Part 3: Validation against experimental data［J］. International
Journal of Vehicle Design, 1991, 12(2): 217-228.
［16］ ABAQUS Inc. Abaqus Scripting User's Manual［M］. Providence, Rhode Island: ABAQUS, 2016.
［17］邓辉咏，王炎，郝刚，等.一种适用复杂非线性黑箱系统的参数灵敏度分析方法［J］.火炮发射与控制学报，2016，37(1)：12-16.
DENG Huiyong, WANG Yan, HAO Gang, et al. A parameter sensiti-vity analysis method suitable for complex non-linear black-box system［J］. Journal of Gun Launch &
Control, 2016, 37(1): 12-16.

[1]	林骋. 基于ABAQUS的跨座式单轨钢轨道梁应力状态分析[J]. 重庆交通大学学报（自然科学版）, 2021, 40(03): 72-77.
[2]	刘朝涛,狄科宏,杜子学,杨震. 跨座式单轨弓网耦合主动控制研究[J]. 重庆交通大学学报（自然科学版）, 2021, 40(02): 129-135.
[3]	文孝霞，姜路，杜子学，孔得旭. 基于不同焊缝结构的单轨车辆转向架构架疲劳分析[J]. 重庆交通大学学报（自然科学版）, 2021, 40(01): 134-139.
[4]	杜子学，杨进. 中小运量跨座式单轨车体疲劳寿命预测[J]. 重庆交通大学学报（自然科学版）, 2019, 38(06): 109-114.
[5]	王晨云，丛聪，陈城辉. 新型快速运输系统比较研究及应用展望[J]. 重庆交通大学学报（自然科学版）, 2012, 31(增1): 594-598.
[6]	杜子学，马加兵. 液压减振器失效对跨座式单轨车辆动力学性能的影响分析[J]. 重庆交通大学学报（自然科学版）, 2021, 40(11): 142-148.
[7]	杜子学1,常聪1,杨震1,汪林峰2. 水平轮胎结构形式对跨座式单轨车辆运行平稳性的影响[J]. 重庆交通大学学报（自然科学版）, 2022, 41(01): 127-132.
[8]	杜子学，李云龙. 新型双轴宽轮距跨座式单轨车辆曲线通过性分析[J]. 重庆交通大学学报（自然科学版）, 2022, 41(04): 133-138.

走行轮轮胎带束层帘线性能参数对轮胎磨损影响规律研究

Influence Rule of Belt Cord Performance Parameters of Running Wheel Tire on Tire Wear

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 8

编辑推荐

Metrics