Further Determination of Friction Coefficients between High-Strength
Zinc-Coated Steel Wires in Stay Cables

doi:10.3969 /j.issn.1674-0696.2012.02.04

Journal of Chongqing Jiaotong University(Natural Science) ›› 2012, Vol. 31 ›› Issue (2): 188-190.DOI: 10.3969 /j.issn.1674-0696.2012.02.04

Previous Articles Next Articles

Further Determination of Friction Coefficients between High-Strength Zinc-Coated Steel Wires in Stay Cables

Chen Can^1,2，Zheng Gang²，Yan Haijiao^1,2，Du Yuan^1,2

1. School of Civil Engineering ＆ Architecture，Chongqing Jiaotong University，Chongqing 400074，China; 2. China Merchants Chongqing Communication Research ＆ Design Institute Co. ，Ltd. ，Chongqing 400067，China

Received:2011-08-25 Revised:2011-09-07 Online:2012-04-15 Published:2014-10-31

拉索高强镀锌平行钢丝摩擦系数的进一步确定

陈璨^1,2，郑罡²，燕海蛟^1,2，杜渊^1,2

1. 重庆交通大学土木建筑学院，重庆400074; 2. 招商局重庆交通科研设计院有限公司，重庆400067

作者简介:陈璨( 1987 － ) ，女，重庆人，硕士研究生，主要从事斜拉索局部弯曲应力方面的研究。E-mail: chencan545@163． com。
基金资助:
国家自然科学基金项目( 50878220 ) | 重庆市自然科学基金项目( CSTC，2008BA6039 ) | 交通运输部西部交通建设科技项目 ( 200731882233)

Abstract

Abstract: Accurate identification of friction coefficients between steel wires is one of the prerequisites for analyzing the local bending stresses in stay cables． In order to determine the friction coefficients between high-strength zinc-coated steel wires in stay cables accurately，the test is performed by using specially designed equipment to exert pressure on the wire within the required pressure． The pressure applied by the test can achieve the value of pressure suffered by the stay cables of cablestayed bridge in the actual work． Within the required pressure，a series of the friction coefficients between steel wires in stay cables are determined under certain pressure． Friction behavior and friction coefficients trends can be described: as the pressure increases，friction coefficients between high-strength zinc-coated steel wires decrease significantly． However，when positive pressure increases to a certain value，the decline of friction coefficients is slowing down．

Key words: high-strength zinc-coated steel wires, friction coefficients, positive pressure, changing trend

摘要： 准确识别斜拉索内平行钢丝间的摩擦系数值是确定拉索局部弯曲应力大小的必要的前提条件。为了进一步精确测定斜拉索高强镀锌平行钢丝摩擦系数值，利用自行设计的装置在所需加力范围内对钢丝施加正压力，所施加的正压力可以达到实桥中拉索工作时所受的正压力值的大小，在加力范围内，测定出一系列钢丝间的摩擦系数值。试验结果表明: 随着正压压力的增大，斜拉索内高强镀锌平行钢丝的摩擦系数明显降低| 但当压力增大到较大值时摩擦系数的降幅明显减缓。

关键词: 高强镀锌钢丝, 摩擦系数, 正压力, 变化趋势

CLC Number:

U443.38

Chen Can，Zheng Gang，Yan Haijiao，Du Yuan. Further Determination of Friction Coefficients between High-Strength Zinc-Coated Steel Wires in Stay Cables[J]. Journal of Chongqing Jiaotong University(Natural Science), 2012, 31(2): 188-190.

陈璨，郑罡，燕海蛟，杜渊. 拉索高强镀锌平行钢丝摩擦系数的进一步确定[J]. 重庆交通大学学报（自然科学版）, 2012, 31(2): 188-190.

References

[1] 李红，郑罡，陈璨．斜拉索内平行钢丝间摩擦系数的确定[J]．重庆交通大学学报: 自然科学版，2011，30( 2) : 196 － 199．
Li Hong，Zheng Gang，Chen Can． Determination of friction coefficients between steel wires in stay cables[J]． Journal of Chongqing Jiaotong University: Natural Science，2011，30( 2) : 196 － 199．
[2] Zheng Gang，Li Hong． Normal stress between steel wires in the stay-cable [J]． Applied Mechanics and Materials Journal，2011，50 /51: 541 － 546．
[3] 刘亚民．摩擦力与摩擦系数的几点性质[J]．乌伦贝尔学院学报，2006，14( 4) : 67 － 68．
Liu Yamin． Some qualities of friction and friction modulus [J]． Journal of Hulunbeier College，2006，14( 4) : 67 － 68．
[4] 蒋浩民，陈新平，俞宁峰，等．正压力和滑动速度对镀锌钢板摩擦系数的影响[J]．锻压技术，2005， 30( 增刊1) : 129 － 132．
Jiang Haomin，Chen Xinping，Yu Ningfeng，et al． Effects of contact pressure and sliding velocity on the frictional coefficient of zinccoated sheets [J]． Forging ＆ Stamping Technology，2005，30 ( supp1) : 129 － 132．
[5] 贾毅朝，摩擦与摩擦系数的分析[J]．运城学院学报，2006，24( 2) : 60 － 61．
Jia Yichao． Analysis of friction and friction factors[J]． Journal of Yuncheng University，2006，24( 2) : 60 － 61．
[6] GB /T 5782—2000 六角头螺栓[S]．北京: 中国标准出版社，2001．
[7] 李红．斜拉索内钢丝间联合工作模式对局部弯曲应力的影响[D]．重庆: 重庆交通大学，2010．
[8] 黄平．摩擦学教程[M]．北京: 高等教育出版社，2008．
[9] PTI． Recommendation for Stay Cable Design，Testing and Installation[R]． Phoenix，Arizona: Post-Tensioning Institute，2001．
[10] 杨骏，王刚雷，黄瑶．电镀锌板摩擦系数的影响因数分析[J]．精密成形工程，2009，1( 3) : 14 － 17．
Yang Jun，Wang Ganglei，Huang Yao． The analysis on the influence factors of frictional coefficient of zinc-coated sheet [J]． Journal of Netsshape Forming Engineering，2009，1( 3) : 14 － 17．
[11] 杨兴，张敏，周水兴．影响矩阵法在斜拉桥二次调索中的应用[J]．重庆交通大学学报: 自然科学版， 2009，28( 3) : 508 － 511．
Yang Xing，Zhang Min，Zhou Shuixing． Application of influence matrix method to secondary cable-adjustment of cable-stayed bridges[J]． Journal of Chongqing Jiaotong University: Natural Science，2009，28( 3) : 508 － 511．

Further Determination of Friction Coefficients between High-Strength Zinc-Coated Steel Wires in Stay Cables

拉索高强镀锌平行钢丝摩擦系数的进一步确定

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 2

Recommended Articles

Metrics

[1]	Tang Lin, Xiao Shengxie, Wei Liangwen. Analysis of Energy Transfer on Bridges Based on Seismic Elements [J]. Journal of Chongqing Jiaotong University(Natural Science), 2015, 34(5): 1-4.
[2]	Wang Miao-lin,Hou Bao-jian. Changes of Annual Runoff Distribution in Upper Streams of Yangtze River Basin [J]. Journal of Chongqing Jiaotong University(Natural Science), 2012, 31(4): 873-876.