Research on Shrinkage Performance of Dense Skeleton Based on Lime Fly-Ash Stabilized Aggregate

doi:10.3969 /j.issn.1674-0696.2013.02.10

Journal of Chongqing Jiaotong University(Natural Science) ›› 2013, Vol. 32 ›› Issue (2): 215-0219.DOI: 10.3969 /j.issn.1674-0696.2013.02.10

Previous Articles Next Articles

Research on Shrinkage Performance of Dense Skeleton Based on Lime Fly-Ash Stabilized Aggregate

Ma Shibin¹，Liu Junqin¹，Guo Jianning¹，Wang Lijie²，Chen Xi¹

¹School of Civil Engineering，Hebei University of Technology，Tianjin 300400，China; ² School of Architecture ＆ Art Design，Hebei University of Technology，Tianjin 300400，China

Online:2013-04-15 Published:2018-01-26

骨架密实型二灰碎石基层的收缩性能

马士宾¹，刘俊琴¹，郭建宁¹，王丽洁²，陈曦¹

¹河北工业大学土木学院，天津300400;² 河北工业大学建筑与艺术设计学院，天津300400

作者简介:马士宾( 1974—) ，男，河北保定人，副教授，博士，主要从事路基路面方面的研究。
基金资助:
河北省科技支撑计划项目( 12217636)

Abstract

Abstract: Dry shrinkage performance of lime fly-ash macadam was analyzed with different mix proportions，which was based on the indices of water loss rate，dry shrinkage strain and shrinkage coefficients． By regression analysis，the relation of accumulative dry shrinkage amount with time and accumulative water loss rate was got． Through temperature shrinkage test the relation between temperature shrinkage coefficient and temperature range was studied，and the relation between average temperature shrinkage coefficient and maximum temperature shrinkage coefficient was researched． The results show that: dry shrinkage performance with lime fly-ash stabilized aggregate in gravelly conditions is superior to the normal lime fly-ash macadam mixture． Dry shrinkage performance is in different orders after forming the specimens at early and late time with differentmix proportions． Dry shrinkage performance with mix proportion of 8 ∶ 12 ∶ 80，6 ∶ 14 ∶ 80，8 ∶ 17 ∶ 75 are superior to 5 ∶ 10 ∶ 75． It is reasonable that using temperature shrinkage coefficients of 0 ～－ 10℃ to evaluate the temperature shrinkage performance of lime fly-ash stabilized aggregate．

Key words: lime fly-ash macadam mixture, dry shrinkage performance, temperature shrinkage performance, mix proportion

摘要： 基于失水率、干缩应变、干缩系数等指标，研究了不同配合比条件下二灰碎石混合料的干缩性能; 回归分析了累计干缩量与时间、累计失水率的关系; 通过温缩试验研究了温缩系数与温度区间、平均温缩系数与最大温缩系数的关系。试验结果表明: 多碎石条件下的二灰稳定碎石干缩性能优于常规配比的二灰稳定碎石混合料。配合比分别为8 ∶ 12 ∶ 80，6∶ 14 ∶ 80，8∶ 17 ∶ 75 的二灰碎石混合料干缩性能均优于配合比为5 ∶ 10 ∶ 75; 评价材料温缩性能时以0 ～－ 10 ℃之间的温缩系数为标准较为合理。

关键词: 二灰碎石混合料, 干缩性能, 温缩性能, 配合比

CLC Number:

TU746.2

Ma Shibin，Liu Junqin，Guo Jianning，Wang Lijie，Chen Xi. Research on Shrinkage Performance of Dense Skeleton Based on Lime Fly-Ash Stabilized Aggregate[J]. Journal of Chongqing Jiaotong University(Natural Science), 2013, 32(2): 215-0219.

马士宾，刘俊琴，郭建宁，王丽洁，陈曦. 骨架密实型二灰碎石基层的收缩性能[J]. 重庆交通大学学报（自然科学版）, 2013, 32(2): 215-0219.

References

［1］张海宾，于明明，李小建．二灰钢渣混合料路用性能试验［J］．重庆交通大学学报: 自然科学版， 2011， 30( 6) : 1344-1346． Zhang Haibin，Yu Mingming，Li Xiaojian． Pavement performance of lime-fly ash slag mixture ［J］． Journal of Chongqing Jiaotong University: Natural Science，2011，30( 6) : 1344-1346．［2］吴超凡．半刚性基层材料的干缩性能研究［J］．公路，2007( 10) : 184-189． Wu Chaofan． Research on dry shrinkage properties of semi-rigidbase materials ［J］． Highway，2007( 10) : 184-189．［3］黄煜镔．水泥稳定碎石基层收缩裂缝综合防治试验［J］．重庆大学学报，2006，11( 11) : 550-553． HuangYubing． Test study on the synthetic control of shrinkage cracking on the base of cement stabilized crushed rock ［J］． Journal of Chongqing University，2006，11( 11) : 550-553．［4］魏连雨，葛景锋．低温养生对二灰稳定碎石路用性能影响研究［J］．公路，2011( 12) : 23-27． Wei Lianyu，Ge Jingfeng． Study on the effect of pavement performance of fly ash lime stabilized crushed rock in low-temperature［J］． Highway，2011( 12) : 23-27．［5］杨红辉，唐娴，郝培文，等．半刚性基层材料抗裂性评价方法［J］．长安大学学报: 自然科学版，2002，2 2( 4) : 13-15． Yang Honghui，Tang Xian，Hao Peiwen， et al． Evaluation method for anti-cracking performance of semi-rigid base course ［J］． Journal of Chang’an University: Natural Science，2002，22 ( 4) : 13-15．［6］陈渊召，张舒畅．三灰碎石抗裂性能研究［J］．公路交通科技，2011，28( 1) : 31-36． Chen Yuanzhao，Zhang Shuchan． Research on crack resistance of lime-fly-ash-cement stabilized macadam ［J］． Journal of Highway and Transportation Research and Development，2011，28( 1) : 31-36．［7］李振霞，陈渊召．不同类型半刚性基层材料性能的试验与分析［J］．长安大学学报: 自然科学版，2012， 32( 1) : 41-46． Li Zhenxia，Chen Yuanzhao． Test and analysis of properties for different types of semi-rigid base materials［J］． Journal of Chang’an University: Natural Science，2012，32( 1) : 41-46．［8］郭朝阳．水泥稳定碎石温缩性能试验研究及工程应用［J］．路面机械与施工技术，2007( 10) : 22-24． Guo Chaoyang． Experiment research on temperature contraction performance of cement stabilized macadam and application ［J］．Pavement Machinery ＆ Construction Technology，2007( 10) : 22-24．

[1]	LING Tianqing1, CHEN Qiaoqiao2, QIN Xin3, ZHANG Jun2. Mix Proportions Design of Pervious Concrete Pavement and Its Performance Influence Factors [J]. Journal of Chongqing Jiaotong University(Natural Science), 2019, 38(03): 38-43.
[2]	ZHAO Shi-hua. Quality control of pump concrete [J]. Journal of Chongqing Jiaotong University(Natural Science), 2002, 21(1): 80-83.
[3]	LI Li, JIANG He. Optimization design of super fine sand concrete mixture for slipform paver in pavement [J]. Journal of Chongqing Jiaotong University(Natural Science), 2000, 19(4): 33-37.

Research on Shrinkage Performance of Dense Skeleton Based on Lime Fly-Ash Stabilized Aggregate

骨架密实型二灰碎石基层的收缩性能

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 3

Recommended Articles

Metrics