Design of Anti-Corrosion of Concrete Bridge

doi:10.3969/j.issn.1674-0696.2013.sup.1.05

Journal of Chongqing Jiaotong University(Natural Science) ›› 2013, Vol. 32 ›› Issue (增1): 746-751.DOI: 10.3969/j.issn.1674-0696.2013.sup.1.05

Previous Articles Next Articles

Design of Anti-Corrosion of Concrete Bridge

Sun Hongyao，Yang Zheng，Xu Xuefeng，Xu Ning

State Key Laboratory of Hydrology-Water Ｒesources ＆ Hydraulic Engineering，Nanjing Hydraulic Ｒesearch Institute，Nanjing 210029，Jiangsu，China

Received:2013-01-26 Revised:2013-03-25 Online:2013-06-30 Published:2015-03-12

混凝土结构桥梁的防腐蚀设计研究

孙红尧，杨争，徐雪峰，徐宁

南京水利科学研究院水文水资源与水利工程科学国家重点实验室，江苏南京210029

作者简介:孙红尧(1965—)，男，江苏盐城人，教授级高级工程师，主要从事腐蚀与防护技术的研究开发。E-mail:rehaha@163.com
基金资助:
国家自然科学基金项目( 51279110) ; 交通运输部西部交通建设项目( 200631822302-02)

Abstract

Abstract: In designing high durability concrete，auxiliary durability protective measures of the reinforced concrete should be taken． The method of environmental classification was introduced，and the applicable anti-corrosion measures under different environmental conditions were put forward． Meanwhile，several new materials and new technologies developed were briefly introduced． Finally，the recommendation that the concrete structure designer should improve the communication with corrosion resistant designer was proposed．

Key words: reinforced concrete, anti-corrosion, design, bridge, coating

摘要： 在设计高耐久性混凝土的同时应对钢筋混凝土采取耐久性辅助防护措施。介绍了环境分类的方法，并提出了不同环境条件下可适用的防腐蚀措施，同时简单介绍了研究开发的几种新材料和新技术，建议混凝土结构设计人员应与防腐蚀设计人员加强沟通和交流。

关键词: 钢筋混凝土, 防腐蚀, 设计, 桥梁, 涂料

CLC Number:

U442.51

Sun Hongyao，Yang Zheng，Xu Xuefeng，Xu Ning. Design of Anti-Corrosion of Concrete Bridge[J]. Journal of Chongqing Jiaotong University(Natural Science), 2013, 32(增1): 746-751.

孙红尧，杨争，徐雪峰，徐宁. 混凝土结构桥梁的防腐蚀设计研究[J]. 重庆交通大学学报（自然科学版）, 2013, 32(增1): 746-751.

References

[1]赵铁军.混凝土渗透性[M].北京: 科学出版社，2 006: 1-4．
Zhao Tiejun.Permeability of Concrete [M].Beijing: Science Press，2006: 1-4．
[2]陈艾荣.公路桥梁混凝土结构耐久性设计指南[M].北京: 人民交通出版社，2 012．
Chen Airong.Design Guide of Highway Bridge Durability of Concrete Structures [M].Beijing: China Communications Press， 2012．
[3]郭保林.透水模板衬里的常见使用细节及工程表现[J].混凝土世界， 2012， 39(9): 80-86．
Guo Baolin.The common use details and project performance of controlled permeable formwork liner [J].China Concrete，2012， 39(9): 80-86．
[4]徐雪峰，蔡跃波.新型纳米Al2O3 /ZrO2 抗冲磨面层涂料的研究 750 重庆交通大学学报(自然科学版)第32 卷 [J].新型建筑材料，2 011(5): 63-65．
Xu Xuefeng，Cai Yuebo.Study on Nano-Al2O3 /ZrO2 wear-resistant coating [J].New Building Materials，2011(5): 63-65．
[5]沈春林.水泥基渗透结晶型防水材料[M].北京: 化学工业出版社， 2007．
Shen Chunlin.Cementitious Capillary Crystalline Waterproofing Materials [M].Beijing: Chemical Industry Press，2007．
[6]孙红尧，韩忠奎，任红伟，等.水性氟树脂涂料在桥梁钢结构上的应用[J].腐蚀与防护，2 010，3 1(6): 455-458．
Sun Hongyao，Han Zhongkui，Ｒen Hongwei，et al.Application of waterborne fluorine resin coatings to steel structure of bridge [J]． Corrosion ＆ Protection，2010，31(6): 455-458．
[7]徐雪峰，孙红尧，桂玉枝.混凝土桥梁耐酸雨防腐蚀涂料[J]．腐蚀与防护，2 009， 30(6): 404-406．
Xu Xuefeng，Sun Hongyao，Gui Yuzhi.Acid rain resisting coating for concrete bridge [J].Corrosion ＆ Protection，2009，30 (6 ): 404-406．
[8]单国良，蔡跃波，林宝玉，等.丙烯酸酯共聚乳液水泥砂浆作为修补加固防腐新材料的应用[J].工业建筑，1 995，25(12): 32- 36．
Shan Guoliang，Cai Yuebo，Lin Baoyu，et al.The application of acrylate copolymer emulsion cement mortar as anti-corrosion materials for repairing and strengthening construction [J].Industrial Buildings，1995，25(12): 32-36．
[9]Saraswathya V，Song H W.Evaluation of cementitious repair mortars for corrosion resistance [J].Portugaliae Electrochimica Acta， 2008，26: 417-432．
[10]Cramer S D，Bullard S J，Covino B S，et al.Carbon Paint Anode for Ｒeinforced Concrete Bridges in Coastal Environments[C]． Houston，USA: NACE International，2002．

[1]	ZHOU Jianting1,2, LI Ya2, ZHANG Hong2, XIA Runchuan2, YANG Wenqi2. Two Point Corrosion Test Study of Steel Strands Based on Spontaneous Magnetic Flux Leakage Detection [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(07): 74-81.
[2]	ZHANG Hua1, ZHANG Zhengqi2, CHENG Gao3,4, TIAN Boke1. Rational Distance of Pile Foundation in Precipitous Cliff Section of Loess Area [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(07): 93-98.
[3]	LIU Jinchun, SONG Zixuan, LIANG Dong. Spatial Effect Analysis of Single Box Three Chambers Continuous Girder Bridge under Transverse Temperature Gradient and Eccentric Vehicle Load [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(06): 80-86.
[4]	ZHENG Zhi1,2, GENG Bo2, YUAN Pei2, LI Songlin2, HU Zhengtao3. Experimental Study on a New Connection Structure of Anti-collision Device for Pier Composite Materials [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(05): 66-73.
[5]	ZHANG Yang1, QU Shaoqin1, LU Jiuzhang2, HUO Wenbing3. Method of Fiber Aligning in UHPC and Its Influence on the Tensile Performance [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(05): 74-80.
[6]	DONG Yuwen1, YU Xin2, QIN Yao1, WANG Zongbo1. Effect of Freeze-Thaw Cycles and Corrosion on Bond Behavior of Reinforced Concrete [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(05): 81-86.
[7]	FU Lilei. Correlation Function Method for Parameter Identification Based on Random Excitation Response [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(04): 70-75.
[8]	SU Xiaobo1, XIAO Lin2. Model Test and Numerical Simulation Research on Reasonable Structure of Steel-Concrete Composite Section in Space Rigid Frame [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(04): 76-82.
[9]	LIANG Zongbao 1, CHAI Jie1, NA Shouyong2, MA Tianli1, TANG Yu1. Validity Analysis of Bridge Health Monitoring Data Based on Deep Learning [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(03): 78-83.
[10]	WANG Min1,2, SHANG Fei1, XIAO Li1, BAO Guangzhi3. Composite Beam Fatigue Damage Law of Steel Bridge Deck Gussasphalt Pavement [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(03): 84-88.
[11]	ZHANG Aifeng, LIU Shaokang, YAO Miaomiao, ZHEN Chunbo. Influencing Factors of Structural Damage and Ship Impact Force in Ship-Bridge Collision [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(03): 121-127.
[12]	TANG Qizhi1, XIN Jingzhou1,2, ZHOU Jianting1, FU Lei1,3, ZHANG Jun4. Damage Identification of Corroded RC Arch Based on Time Series Analysis:Simulation and Verification [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(02): 69-77.
[13]	RONG Xian1, 2, YANG Hongwei1, ZHANG Jianxin1, 2. Experimental Research on Hysteresis Behavior of Prefabricated Concrete Beam-Column Joint with Steel End Connector [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(02): 78-82.
[14]	LIU Xiaohui, XU Yang, CHEN Sitian, XU Lueqin. Seismic Response Analysis of Pedestrian Suspension Bridge [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(01): 65-71.
[15]	JU Liping1, WANG Yinhui2, LU Xiaohong3, SHAN Jidong4. Failure Mode Analysis of Reinforced Concrete Box Girder under Impact of a Falling Cargo from Passing Truck [J]. Journal of Chongqing Jiaotong University(Natural Science), 2021, 40(01): 72-78.

Design of Anti-Corrosion of Concrete Bridge

混凝土结构桥梁的防腐蚀设计研究

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics